HYG-5342-97
Fermented or brined products, such as dill cucumbers or sauerkraut, cure for several weeks. Curing changes the color, flavor, and texture of the product. Lactic acid produced during fermentation helps preserve the product. Satisfactory products can be obtained only when
quality ingredients are used and proper procedures followed. Correct proportions of vegetables, salt, vinegar, and spices are essential.
Ingredients
Cabbage--Cabbage composition differs with the variety and growing conditions. Mature, large-headed types, weighing 6 to 15 pounds with a
solid, white interior, are the most desirable for kraut. Red cabbage may be used but makes an unattractive product.
Cucumbers--Select fresh, firm unwaxed cucumbers about 4 inches long. Cucumbers deteriorate rapidly, especially at room temperature. For best results, use varieties developed for pickling.
Salt--Use non-iodized salt; iodine can prevent the bacterial fermentation. Canning or pickling salt can be purchased at most supermarkets. Changing salt proportions or using a reduced-sodium salt substitute in fermented products is not recommended because the
product will not ferment correctly.
Spices--Use fresh, whole spices for best flavor in pickles.
Equipment
The fermentation equipment must be washed in hot sudsy water and rinsed well with very hot water before use.
Suitable Containers
A 1-gallon container is needed for each 5 pounds of fresh vegetables.
A 5-gallon stone crock is the ideal size for fermenting about 25
pounds of fresh cucumbers or shredded cabbage. Food-grade plastic and
glass containers are excellent substitutes for stone crocks. Other 1-
to 3-gallon, non-food grade plastic containers may be used if lined
inside with a clean food-grade plastic bag. Be certain that foods
contact only food-grade plastics. Do not use garbage bags, trash
liners, or plastic buckets not meant for food use.
Covers and Weights
Cabbage and cucumbers must be kept 1 to 2 inches under brine while
fermenting. Insert a dinner plate or glass pie plate inside the
fermentation container. The plate must be slightly smaller than the
container opening, yet large enough to cover most of the shredded
cabbage or cucumbers. To keep the plate under the brine, weight it
down with 2 to 3 sealed quart jars filled with water. Covering the
container opening with a clean, heavy bath towel helps prevent
contamination from insects and molds. The plate also can be weighted
down with a large food-grade plastic bag filled with 3 quarts of water
containing 4 1/2 Tablespoons of salt. Be sure to seal the plastic bag.
Freezer bags sold for packaging turkeys are suitable for use with the
5-gallon containers.
Scales and Utensils
Household scales will be needed if the recipe specifies ingredients by
weight.
When heating pickling liquids, use unchipped enamelware, stainless
steel, aluminum, or glass utensils. Other metals may cause undesirable
color changes in the pickles or form undesirable compounds.
| Fermenting temperatures and times
|
| Temperature | Time | Comments |
| below 55 degrees F | -- | product may not ferment |
| 55-65 | 5-6 weeks |
| 70-75 | 3-4 | ideal temperature |
| above 80 | -- | product may soften or spoil
|
Can I make sauerkraut in the canning jar?
It is very difficult to make sauerkraut safely in this manner. Because
of the high risk for spoilage, this procedure is not recommended.
Recipes
Fermented Dill Pickles (by the gallon)
Use the following quantities for each gallon capacity of your container.
4 pounds of 4-inch pickling cucumbers
2 Tablespoons dill seed, or 4 to 5 heads fresh or dry dill weed
1/2 cup salt
1/4 cup vinegar (5 percent)
8 cups water and one or more of the following ingredients:
2 cloves garlic (optional)
2 dried red peppers (optional)
2 teaspoons whole mixed pickling spices (optional)
Wash cucumbers. Remove blossom end and discard, leaving 1/4 inch of
stem attached.
Place half the dill and spices on bottom of a clean, suitable
container. Add cucumbers, remaining dill, and spices.
Dissolve salt in vinegar and water and pour over cucumbers. Add
suitable cover and weight.
Ferment pickles. Check the container several times a week and promptly
remove surface scum or mold. If the pickles become soft, slimy, or
develop a disagreeable odor, discard them.
Fully fermented pickles may be stored for about 4 to 6 months in the
refrigerator.
Canning fully fermented pickles is a better way to store them. To can
them, pour the brine into a pan, heat slowly to a boil, and simmer 5
minutes. Filter brine through paper coffee filters to reduce
cloudiness, if desired.
Fill jars with pickles and hot brine, leaving 1/2-inch headspace.
Adjust lids and process as below, or use the low-temperature
pasteurization treatment.
| Process time for Fermented Dill Pickles in a boiling-water canner
|
| | Process time at altitudes of |
| Style of pack | Jar size | 0-1,000 ft. | 1,001-3,000 ft. |
| Raw | Pints | 10 min. | 15 min. |
| Quarts | 15 | 20
|
Low-temperature Pasteurization
The following treatment results in a better product texture but must
be carefully managed to avoid possible spoilage. Place jars in a
canner filled halfway with warm (120 degrees F to 140 degrees F)
water. Add hot water to a level 1 inch above jars. Heat the water
enough to maintain 180 to 185 degrees F water temperature for 30
minutes. Check with a food thermometer to be certain that the water
temperature is at least 180 degrees F during the entire 30 minutes.
Temperatures higher than 185 degrees F may cause unnecessary softening
of pickles. Use only for brined pickles when recipe indicates.
Quick Fresh-Pack Dill Pickles
8 pounds of 3- to 5-inch pickling cucumbers
2 gallons water
1 1/4 cups canning salt
1 1/2 quarts vinegar (5 percent)
1/4 cup sugar
2 quarts water
2 Tablespoons whole mixed pickling spice
3 Tablespoons whole mustard seed (1 teaspoon per pint jar)
14 heads of fresh dill (1 1/2 heads per pint jar) or
4 1/2 Tablespoon dill seed (1 1/2 teaspoon per pint jar)
Yields 7 to 9 pints
Wash cucumbers. Cut 1/16 inch slice off blossom end and discard, but
leave 1/4 inch of stem attached.
Dissolve 3/4 cup salt in 2 gallons water. Pour over cucumbers and let
stand 12 hours. Drain.
Combine vinegar, 1/2 cup salt, sugar, and 2 quarts water. Add mixed
pickling spices tied in a clean white cloth. Heat to boiling.
Fill jars with cucumbers. Add 1 teaspoon mustard seed and 1 1/2 heads
fresh dill per pint. Cover with boiling pickling solution, leaving 1/2
inch headspace. Adjust lids and process as below or use the low
temperature pasteurization treatment.
Recommended process time for Quick Fresh
Pack
Dill Pickles in a boiling-water canner
|
| | Process time at altitudes of |
| Style of pack | Jar size | 0-1,000 ft. | 1,001-6,000 ft. |
| Raw | Pints | 10 min. | 15 min. |
| Quarts | 15 | 20
|
Sauerkraut
10 pounds shredded cabbage
6 Tablespoons canning or pickling salt
Yields 3 to 4 quarts
Prepare 5 pounds of cabbage at a time. Discard outer leaves and any
insect-damaged areas. Rinse heads under cold running water and drain.
Cut heads in four wedges. Discard cores. Shred or slice to a thickness
of a quarter.
Put 5 pounds of shredded cabbage in a suitable fermentation container,
and add 3 Tablespoons of salt. Mix thoroughly, using clean hands. Pack
firmly until salt draws juices from cabbage.
Repeat shredding, salting, and packing until all cabbage is in the
container. Be sure the container is deep enough so that its rim is at
least 4 or 5 inches above the cabbage.
If juice does not cover cabbage, add boiled and cooled brine (1 1/2
Tablespoons of salt per quart of water).
Add plate and weights. Cover container with a clean towel. Ferment
cabbage.
If you weigh the cabbage down with a brine-filled bag, do not disturb
the crock until normal fermentation is complete (when bubbling
ceases). If y ou use jars as weight, check the kraut two to
three times per week and remove scum if it forms.
Fully fermented kraut may be kept tightly covered in the refrigerator
for several months or it may be canned as follows:
Hot pack--Bring kraut and liquid slowly to a boil in a large kettle,
stirring frequently. Remove from heat and fill jars firmly with kraut
and juices, leaving 1/2-inch headspace. Add lid and ring, then
process.
Raw pack--Fill jars firmly with kraut and cover with juices, leaving 1/2-inch headspace. Add lid and ring, then process.
| Process time for Sauerkraut in a boiling-water canner
|
| | Process time at altitudes of |
| Style of pack | Jar size | 0-1,000 ft. | 1,001-3,000 ft. |
| Hot | Pints | 10 min. | 15 min. |
| Quarts | 15 | 20 |
| Raw | Pints | 20 | 25
|
Cabbage and cucumbers must be kept 1 to 2 inches under brine while fermenting. Use a proper weighting method, as suggested.
References:
Information Complied by Marcia Jess, Extension Agent, Family and Consumer Sciences
All educational programs conducted by Ohio State University Extension are available to clientele on a nondiscriminatory basis without regard to race, color, creed, religion, sexual orientation, national origin,
gender, age, disability or Vietnam-era veteran status.
Keith L. Smith, Associate Vice President for Ag. Adm. and Director, OSU Extension. TDD No. 800-589-8292 (Ohio only) or 614-292-1868
| 
